The water was brought in a ditch or flume to the top of a high bank, and
then terminated in a tight box. To this box was attached a large hose
made by hand out of canvas, and a pipe and nozzle attached to the lower
end of the hose. Now as the bank was often 100 feet or more high the
water at this head, when directed through the nozzle against the bank,
fairly melted it away into liquid mud. Imagine us located a mile above
the river on the side of a mountain. We dug at first sluices in the rock
to carry off the mud and water, and after it had flowed in these a
little way a sluice box was put in to pass it through. These were made
on a slope of one in twelve, and the bottom paved with blocks, 3 inches
thick, so laid as to make a cavity or pocket at the corner of the
blocks. After passing the first sluice box the water and gravel would be
run in a bed rock sluice again, and then into another sluice box and so
on for a mile, passing through several sluice boxes on the way.
Quicksilver was placed in the upper sluice boxes, and when the particles
of gold were polished up by tumbling about in the gravel, they combined
with the quicksilver making an amalgam.
The most gold would be left in the first sluice boxes but some would go
on down to the very last, where the water and dirt was run off into the
river. They cleaned up the first sluices every week, a little farther
down every month, while the lower ones would only be cleaned up at the
end of the season.
In cleaning up, the blocks would be taken out of the boxes, and every
little crevice or pocket in the whole length of the sluice cleaned out,
from the bottom to the top, using little hooks and iron spoons made for
the purpose.
The amalgam thus collected was heated in a retort which expelled the
quicksilver in vapor, which was condensed and used again.
When they first tried hydraulic work a tinsmith made a nozzle out of
sheet iron, but when put in practice, instead of throwing a solid
stream, it scattered like an shotgun, and up at Moore's Flat they called
the claims where they used it the "shotgun" claims.
From that time great improvements were made in hydraulic apparatus until
the work done by them was really wonderful.
In 1850 there lived at Orleans Flat and Moore's Flat, in Nevada County a
few young, energetic and very stirring pioneers in the persons of lads
from 10 to 15 years of age, always on the search for a few dimes to
spend, or add to an already hoarded store, and the mountain air, with
the wild surroundings, seemed to inspire them always with lively vigor,
and especially when there was a prospect of a two-bit piece not far
ahead.